EGO LM2100E-SP Lawn Mower Manual

The EGO LM2100E-SP is a 21-inch Cordless Electric Lawn Mower powered by a 56V ARC Lithium™ battery, featuring a brushless motor, 3-in-1 functionality (mulch, bag, side-discharge), 6-position height adjustment, weather-resistant construction, LED headlights, push-button start, and a folding handle for storage. Below are key sections for safety, features, assembly, operation, maintenance, and troubleshooting.

Features at a Glance

Key components: 56V ARC Lithium™ Battery, Rapid Charger, Brushless Motor Deck, 21-inch Steel Blade, 6-position Height Adjustment Lever, Folding Handle, LED Headlights, 3-in-1 Clipping Management System.

Assembly Instructions

Unpack and inspect all contents. Assemble on a flat, stable surface.

1. Attach the Lower Handle: Align lower handle with deck brackets and secure with provided bolts.
2. Attach the Upper Handle: Connect upper handle to lower handle, secure with knobs or bolts.
3. Install the Grass Bag: Attach bag holder to rear deck and clip grass bag into place.
4. Install the Battery: Insert battery into battery port until it clicks.
5. Attach Side-Discharge Chute (if needed): Snap chute into side port for side-discharge mode.

WARNING! Ensure mower is powered OFF and battery is removed during assembly. Tighten all fasteners securely.

First-Time Setup

Prepare mower for initial use.

1. Charge Battery: Connect battery to charger; charge fully before first use (LED indicates status).
2. Select Cutting Mode: Choose mulch, bag, or side-discharge by installing appropriate chute or plug.
3. Adjust Cutting Height: Use height adjustment lever to set desired cutting height.
4. Insert Safety Key: Insert key into slot near handle.
5. Test Operation: In a safe area, press and hold safety lever, then press start button to test.

CAUTION! Read all safety instructions before operation. Keep bystanders and pets away.

Specifications

• Cutting Width: 21 inches.
• Power Source: 56V ARC Lithium™ Battery (included).
• Motor Type: Brushless.
• Cutting Height Range: 1.5 - 4 inches (6 positions).
• Clipping Options: Mulch, Bag (2.6 bushel capacity), Side-Discharge.
• Start System: Push-button electric start.
• Lights: Integrated LED headlights.
• Handle: Folding, adjustable.
• Deck Material: Steel.
• Weight (without battery): Approximately 40 lbs.

Controls and Settings

Main Controls located on the handle.

Handle Controls: Safety Lever (must be held to operate), Start/Stop Button, Battery Fuel Gauge, Height Adjustment Lever.

Operation: Press and hold safety lever, then press start button to begin mowing. Release safety lever to stop blade. Settings: Height adjustment via lever (1.5, 2, 2.5, 3, 3.5, 4 inches). Clipping mode selected by installing mulch plug, grass bag, or side-discharge chute.

Battery & Charging

Use only EGO 56V ARC Lithium™ batteries and charger.

1. Charging: Connect battery to charger; plug charger into 120V outlet. LED indicates charging (red) and complete (green).
2. Runtime: Varies based on grass conditions and height; typical 45-60 minutes per charge.
3. Storage: Store battery in cool, dry place. Charge fully before long storage.
4. Battery Gauge: Press button on battery to check charge level (LED indicators).

Tip: For best performance, charge battery at room temperature. Do not expose battery to extreme heat or cold.

Mowing Operation

Supports standard mowing with three clipping options.

1. Pre-Mow Check: Ensure area is clear of debris, stones, and toys. Install desired clipping accessory.
2. Starting: Insert safety key. Hold safety lever, press start button.
3. Mowing Technique: Use overlapping passes for even cut. Mow in dry conditions for best results.
4. Stopping: Release safety lever; blade stops within 3 seconds.
5. Emptying Bag: Stop mower, remove safety key. Detach and empty grass bag when full.
6. Switching Modes: Stop mower and remove key before changing mulch plug, bag, or chute.

WARNING! Always wear eye protection and sturdy footwear. Do not mow on steep slopes. Keep hands and feet away from cutting deck.

Height Adjustment

Adjust cutting height to match grass conditions.

1. Locate Adjustment Lever: Found on each wheel or central lever.
2. Select Height: Move lever to desired setting (1.5 to 4 inches). Ensure all wheels are at same height.
3. Test: Mow a small area to verify cut quality.

Note: For first mow of season or long grass, set to highest setting, then lower gradually.

Care & Maintenance

Regular maintenance ensures optimal performance and longevity.

1. After Each Use: Clean underside of deck (remove battery first). Wipe exterior with damp cloth.
2. Blade Care: Periodically inspect blade for damage or dullness. Sharpen or replace as needed.
3. Wheel Care: Check wheels for free movement; lubricate axles if necessary.
4. Storage: Fold handle, store in dry location. Remove battery and store separately.
5. Winter Storage: Charge battery fully, store in cool, dry place above freezing.

CAUTION! Always disconnect battery before performing any maintenance. Do not use water or harsh chemicals to clean.

Safety Information

Read and follow all safety instructions to prevent injury.

• Wear appropriate protective equipment: safety glasses, hearing protection, long pants, sturdy shoes.
• Clear mowing area of objects that could be thrown by blade.
• Do not operate on wet grass or steep slopes (over 15 degrees).
• Keep bystanders, children, and pets at least 50 feet away.
• Never carry mower while it is running.
• Use only EGO-approved batteries and chargers.
• Disconnect battery before cleaning, maintenance, or storage.

DANGER! Blade rotates at high speed. Keep hands and feet away from deck at all times.

Troubleshooting

Reset: Remove battery for 30 seconds, then reinsert.

Service: For technical support, visit www.egopowerplus.com or contact 1-855-EGO-5656.